Featured Project CARS 2 - PC Update 1.6.0.0 - Release Notes

Discussion in 'Newsfeed' started by t0daY, Jun 6, 2018.

  1. t0daY
    OFFLINE

    t0daY Head of RSR Admin

    3,886
    2,791
    Aug 2, 2016
    Patch Notes

    Various improvements, fixes and optimisations.
    • Fixed occasional stability issues.
    • Improved usability of in-game tools.
    • Improved AI ability at various tracks.
    • Improved the penalty system.
    • Optimised tyre wear in wet conditions.
    • Optimisations to LiveTrack at various tracks.
    • Improved track-limit zones.
    • Other miscellaneous fixes.

    The 24-Hours of Le Mans comes to Project CARS 2 with the “Spirit of Le Mans” Pack, available as a standalone purchase, or as part of the Project CARS 2 Season Pass.

    Experience two of the most thrilling eras of sportscar racing at the world’s most evocative endurance race and discover the true Spirit of Le Mans as today’s LMP1 heroes meet yesteryear’s electrifying prototypes in one classic Pack that captures the pure essence of the 24 Heures du Mans.

    Along with the 9 cars (incl. 4 modern LMP1s and epic prototypes from Ferrari [the 512 S and 512 M] and Porsche [the all-winning Porsche 917 LH]), comes the faithfully recreated 1971 track, 5 Career events, and 10 bespoke liveries to bring the Spirit of Le Mans to life like never before.

    Audi R18 e-tron quattro (2016):
    Being that the car was retired after 2016, Audi went the extra mile and provided some impressive reference material for this one; something of a rarity for top-level, high-tech cars. It was possible to fill in the few remaining gaps with data from the 2014 car and make a model which I feel is a very good representation of the real thing in our systems.

    Engine is the same 4.0L turbo diesel they have been using for 6 years with constant, little updates for the regulations. By 2016, being in the 6MJ hybrid that meant reduced fuel flow so it would only make about 520hp peak and it holds that from 3500-4250rpm, which is the entire rev range you use. The ICE drives the rear wheels through a 6-speed sequential (down from 7 in previous years) with ratios that, best I can tell, didn't change through the entire season. We have added in a couple alternate final drive ratios in ours to cater to the wider variety of tracks.

    Up front, the hybrid system had a huge upgrade since 2014. Flywheel is gone and replaced with batteries, with the motor upgraded for 350kW peak power (limited by rule to 300kW at Le Mans). Analyzing on-board telemetry shows the energy store works out to a nice, round 1kWh and the system software does some fancy tricks to send an average of 260-270kW to the wheels during each energy burn. The hybrid system normally cuts off around 260km/h even if there is plenty of energy left in storage; getting up to that speed is what makes lap time, not excessive burn for higher top speed. Our hybrid system can't do all the same tricks as the real thing (steering sensors, GPS, etc.) but it was possible to calibrate for a similar result to the real thing while using the full 6MJ over each lap at Le Mans.

    Aero model is similar to our 2014 car data with more efficiency and less drag to hit the right top speed reference points: ~320km/h at Le Mans, 295 @ CotA. There were some rules changes meant to cut LMP1H downforce in 2016, but the teams surely clawed it all back and cornering performance looks close to the mark on the 2014+ downforce levels. We do have the R18 artwork split to Le Mans and high-downforce variants for liveries. Jussi had a great idea to split our aero model between the two, so the low-drag LM version gets steps 0-5 and high-downforce model has steps 4-10. Choose your variant wisely to suit a track and your own driving style.

    Neatest thing about this one was the detail sent over by Audi in the CAD model. First LMP1 car where we could do an exact model of the suspension geometry to see how they handle sending so much power to the front wheels without harming steering feel. There is an almost absurd amount of caster angle built in, and the front would be better described as multi-link than double wishbone. The front and rear bars of what look like wishbones aren't actually connected at all at the upright, and allow the wheel to move fore-aft slightly when steered. It looks like it shouldn't work at all, but it actually drives great and gives better FFB than approximating a pure double wishbone setup from the same links.


    Porsche 919 Hybrid: This and the Toyota were still active during dev time, so information was a bit more secretive on them. It uses a chunk of its base from the 2016 Audi R18 and the differences are largely due to the power unit.

    Engine here is a 2.0L turbo V4 which Porsche claim generates 'just under' 500hp with the 8MJ fuel flow limits. Mapping out fuel flow, estimated thermal efficiency, boost pressure curves, and all that, we can be pretty certain that it holds at that 500hp (or slightly above) from 5,500rpm right up to the shift point we see in on-board telemetry at 7,800rpm. Augmenting this are electric motors on the front axle for an additional 300kW where the typical strategy is to burn hybrid power up to around 280kph and then let the internal combustion take it from there to top speed in the 313-320kph range depending on traffic/drafting effect. Used like this at the beginning of Le Mans' six long straights, it eats up almost exactly the 8MJ energy allowance per lap while shaving upwards of 10s from the average lap time. Impressive stuff considering that top speed on each of those sections doesn't really change whether using hybrid power or not; just that with hybrid power you are at top speed for almost the entire time. Charging happens with a regenerative braking system like the Audi and also adds a generator on the turbocharger which takes extra energy which would normally dump out the wastegate and directs it into the battery at a rate of up to about 40kW. You will see the battery charge increase during full throttle driving thanks to this.


    Toyota TS050 Hybrid: As is usually the case, three years of rules stability saw the main competitors converge on similar approaches in how to get best performance from the energy they were allowed to use. Where 2014 saw a Toyota take pole position with a lap where its top speed was nearly 40km/h slower than that of Audi's on their fastest lap (336 vs 298), by 2016 the three big teams had all honed in on similar aero and hybrid strategies which saw performance over all segments of a track become quite similar.

    Engine is a 2.4L V6 twin turbo compared to Porsche's 2.0L V4, and both make around the same 500hp in a wide band from 5,000-8,000rpm due to fuel flow restrictions of the 8MJ energy class. Main point where they differ is the hybrid system. Porsche run regenerative braking on the front axle plus an MGH unit taking excess exhaust energy from the turbo to charge a battery which powers a motor on the front axle alone. Toyota don't do turbo-compounding, but do take regenerative braking from both axles and then deploy hybrid energy to both axles as well; the only one of the three 2016 cars to send extra power to the rears via the hybrid system. I like very much what this does to the car’s handling. In the Audi or Porsche, you can sometimes catch yourself out using the hybrid too early when exiting a turn, spin the front wheels a bit and waste time+energy+cornering power. The Toyota, on the other hand, is only pushing 150kW to the front tires instead of 300kW, so it is a little easier to get on the hybrid boost early without upsetting balance of the car. Does a better job at equalizing tire temperatures and wear (at least for my driving) even if there might be instances where it gives up a little performance when the rears can't handle the full 700hp and it kicks into the traction control. Takes a slightly different driving style than the point & shoot Porsche or Audi, but all three are super close in performance over a lap by the end.


    LM P1H 2016 Hybrid use and strategy: One big difference for these 2016 cars is that we've changed the hybrid system to activate on button press rather than throttle input. Rules for the real car don't allow it to be on a button like this, but the real systems are becoming so complex that we can't really copy their action from throttle input alone; it worked fine for the simpler cars of 2014, but not now that everyone is in the high energy categories and working out better energy deployment strategies. Manually controlling the hybrid to match closer what we see done in the real thing has a significant effect on lap times. Avoiding any wasted energy on unimportant parts of the track and saving it for big burns made me about 4s per lap faster in the Porsche and 2s in the Audi; plus it gives a fun push-to-pass feature if you manage to save a little energy while racing closely with anyone.

    The most effective hybrid strategy in these three cars tends to center around finding the slowest corners of a track and burn energy on the exit up to about 260-275km/h. Using more of the battery than that yields diminishing returns and is better saved for a slow spot elsewhere on the track. Run some practice laps at each track to see how the car recharges over a lap and where you might want to save hybrid energy to have a full boost out of the slowest corners.

    Qualifying can change your strategy a bit too; consider Fuji as an example. In a race at Fuji, you would typically save up charge from the second half of a lap and boost out of the final corner to reach a 290km/h top speed early on the long, Start:Finish straight, doing this consistently lap after lap. In qualifying, however, you don’t care about the lap before or after and can use this to your advantage. Exit that last corner and accelerate to about 240km/h, only then using the hybrid for extra top speed of 310+ from the start-finish line into braking for the first corner. Then finish the lap with a long boost right out of the final corner for the best lap time. It doesn’t work for multiple laps in a row, but stringing together a fast second half of the straight to start a lap plus fast first half of the straight to end it shaved over 1s from my typical race pace lap time.

    A similar quirk comes into play at Spa-Francorchamps. Rather than burn all of your energy our of La Source before Eau Rouge, save 50% charge or so for the Kemmel straight afterwards. It is a long, uphill run, and boosting to top speed immediately after Eau Rouge can be a huge win for your lap time. Every track will have unique strategy plays like this, so experiment and keep an eye out for what works best in both qualifying and race situations.


    Porsche 924 Carrera GTP: This one is a funny little piece of history thanks to those three letters at the end of the name - GTP. Porsche had introduced a 924 Turbo model but there was not enough time to meet homologation requirements for it to run in the production GT category as intended. Simple solution: Just run it in the GTP class against other full-on prototypes where the rules were effectively 'have a roof and a minimum weight for your engine size'...300hp disadvantage and road car aerodynamics be damned, the 924 Turbo would be racing!

    There is a fantastic documentary video of the car's restoration over HERE where the drivers all talk about how great 924 GTP was; having some of the best handling they ever experienced...high praise when the group includes five-time Le Mans winner Derek Bell. And that great handling paid off as the race was *very* wet. Despite being a good 50mph down in top speed and lapping 30s slower in qualifying, the 924 GTPs used their strengths to pull off a fantastic result of 6th overall (3rd in class) with the other two cars in 12th and 13th.

    Design-wise, the car is both very similar and very different to the 911 Carrera RSR 2.8 we have in game from the Porsche Legends DLC. The differences, obviously, are that this one is front-engine with a 2.0L turbo 4-cylinder sourced from Audi. Doubling boost pressure from the street 924 Turbo to 2.5bar, it cranks out 320hp with a smooth torque curve and power is fed through a 5-speed manual Getrag G31 much like the road car but with a wide range of ratios to choose from for race use. A clutch-type limited-slip differential with symmetrical 40% lock is standard issue, much like in the 911 Carrera RSR and even 908/03.

    Engine position, roll cage addition, and general lightening of the chassis make for a total car weight of 945kg with 52% rear balance. Suspension uses struts at the front and trailing arms at the rear, like the 911 Carrera RSR; spring and damper settings for that car also work here to great effect. It even used brakes from the 917 parts catalog, another 911 Carrera RSR similarity. For tires, they fit the widest things possible. This car is around 100kg lighter than the BMW M1 Procar and with 160hp less, but it has more rubber at both ends; thing has a surplus of grip in the dry and wet. While it can struggle on top speed tracks, it is so easy to chuck around that time can be made up quickly in twisty sections of tracks and it has come out ahead in testing here at the shorter tracks.


    Porsche 961: A real unicorn here; they only made the one. While Group B and the 959 are largely remembered for rally racing, circuit racing was always part of the plan and the 961 was to be Porsche's customer car in that regard. The end of the Group B era and cost of a 961 compared to competitive Group C machinery cut those plans short and left us with only one example of what was, for nearly 30 years, the only AWD car to race at Le Mans.

    Chassis construction was not all that different than the road-going 959S model from our Porsche Legends DLC. The usual strengthening and lightening measures were undertaken; the highly-computerized AWD system was simplified to a fixed 20:80 power balance front to rear; the 'zero-lift' aerodynamics were bolstered to produce some downforce for the necessary cornering grip at expense of a higher drag coefficient; and the 959 engine, which was in turn a de-tuned 956/962C race engine, was swapped back out for a Group C racing version of the 2.85L twin-turbo flat-6.

    The race-spec engine brings power up to 680hp @ 7,800rpm and drives through a 6-speed gearbox just like from the 959S but with a range of ratios as setup options. For Le Mans, they ran the rear end with a spool axle as a reliability measure (fewer moving parts to break) but you can be sure it would have run a clutch-type LSD at the rear had it raced in a full WSC season; ours does that with a typical 40/60%-lock differential at the rear.

    Wider fenders, mild diffusers on the flat floor, and an aggressive rear spoiler cost about 20% in drag increase over the 959S for a gain of roughly 500lb downforce at 150mph. Not a huge amount, but very welcome to help stabilize the 1150kg car in cornering and under braking. The extra drag limits top speed to 205mph on the Mulsanne straight; about the same as the 959S road car despite the extra power and some way off the top Group C cars it raced against, but still a respectable number.

    Tuning the suspension proved to be not a difficult job at all. The 959S had already forgone the fancy, adaptive, computerized suspension of the 959 Komfort model in favor of fixed-rate dampers and ride height. Turns out that, being some 400kg lighter, the 961 races extremely well on the same springs and dampers of the 959S. Drop the ride height, stiffen the anti-roll bars to account for increased cornering grip from the racing slicks and it is ready to go. Probably my favorite handling car in its class. Maybe not as exciting as the F40LM's turbo lag or Mustang's pure torque, but it inspires huge confidence on corner exits where you can plant the throttle to the floor and let the AWD system pull the car out with just the right amount of slip angle. The Audi 90 IMSA GTO finally has something that can compete with it in the rain.


    Porsche 917LH: The 917LH models are very similar to the 917K at fundamental levels. The main evolution here is in the aerodynamics with a heavy focus on top speed for Le Mans. Early iterations of the LH bodywork were great for drag reduction, but also generated significant aero lift at the rear. That deficit had largely been removed by the 1971 model we’ve simulated here; wind tunnel tests showed about 300lb downforce @ 150mph with a stable balance of 20-25% front. That’s enough to hit a solid 390km/h and feel perfectly comfortable taking the Mulsanne kink flat out.

    The longer bodywork plus other detail changes of the LH model pushed them up above 820kg and closer to 66% rear weight.

    See our Physics of Porsche Legends DLC thread for more notes about the common engine and gearbox used by these cars.

    http://forum.projectcarsgame.com/sho...he-Legends-DLC


    Ferrari 512M & 512S Coda Lunga: In researching this one, the word most often used for it by drivers, owners, and Ferrari's engineering team was 'under-developed'. I suppose that is a fair criticism considering it only took a single race win to the Porsche 917's 17 in the 1970 and 1971 seasons, but you also have to consider that the 917 began life a year earlier in 1969 and benefits from an extra year's worth of development at a time all aspects of car design, aerodynamics chiefly, were moving at a extraordinary pace. That Ferrari were able to win Sebring 1970 in a 512S variant right at the start of its life shows how strong a platform they had.

    The technical directive for 512 was essentially to use as much existing material Ferrari had to build a 917 beater. For this, the engine took castings and design cues from the recent 6.9L 712 Can-Am engine with bore and stroke reduced for a capacity of 4,994cc. It had a slight power advantage over the Porsche flat-12 (610 vs 600hp) and, being a known and tested architecture, was generally reliable and less sensitive to over-revving than the Porsche. Peak power comes between 8,700-9,000rpm and it is happy spinning up to 9,600 if you get favorable winds or a nice draft down the Mulsanne. Drive goes to the rear through a simple, 5-speed gearbox designed in-house and a ramp & plate clutch differential; the similar layout and weight balance means a 75% locking factor works well here as it does in the 917 (some drivers in period preferred using a spool axle). Gear ratio setup was distilled to four crown wheel & pinion options to adjust final drive for top speed of the circuit; the longest, 11/35 (3.182:1), being the choice for Le Mans and getting the Coda Lunga variant up to 230mph.

    Tube-frame chassis for the 512 was essentially carryover from the 612 P Can-Am car. The basic concept and design was standard Ferrari construction of the time (much like how the 908 and 917 variants evolved from the same base) and it all works well. Suspension geometry produces benign handling with nice steering feel, letting you focus on placing the car and putting power to the road. Reading old race reports, it seems the main issue they had was one of quality control and inconsistency where not all 512 chassis were build exactly to the same standard. Teams which had the most success, namely Penske, put a lot of work into extra prep of their cars to make sure the design worked as intended.

    The chassis did have a significant weight disadvantage to the Porsche; tube steel fabrication making for a frame maybe 100kg more than the 917's aluminum chassis. Later 512M examples have a claimed weight of 815kg, but this appears to be a dry weight while true, Le Mans scrutineering weights from 1971 put the cars more in the range of 880kg with fluids included. The 512 S Coda Lunga models weighed in at an average of 940kg.

    Aerodynamics is a big area where the 512 suffered from lack of development. It never saw a wind tunnel (early versions of the 512S even had little road testing because of an unfavorable winter in Sicily) and was drawn largely from past experience about aero ideas which should work in theory. Huge difference to the extensive wind tunnel program of the 917 models, and it showed at Le Mans where the Ferraris typically had between a 6-10mph deficit on similar, long-tail bodywork. Short-tail 512M models will top out around 217mph where the 917LH reaches 240. The 512 S Coda Lunga is good for another 10-15mph, but setting up for that comes with a handling penalty of losing maybe 50% of rear downforce compared to the 512M, which itself is some way behind the 917 for downforce numbers. The Coda Lunga gets very light going over the Mulsanne hump at speed, so be careful with your steering inputs when taking that crest at 230mph.

    That all sounds like it adds up to a car which will just be smoked by the Porsche at every track in game, but truth is they proved quite well balanced in testing during our development. For one thing, the Ferrari ran wider tires at both ends, especially the front (285mm wide vs. 235mm), and that extra grip helps counter the aero deficiencies. Then there is that engine. The air-cooled Porsche flat-12 was a tremendous machine, but it was also a complex design and Porsche's own data shows that it was quite peaky in power production. Its peak of 600hp is only held for a few hundred rpm; go outside of that range and it drops significantly, change up a gear and it might dip below 500hp for an instant. That Ferrari V12, though, was a known design with which they had lots of experience. It's torque curve is much smoother and holds it over 550hp (90% of the peak 610hp) all the way from 7,500 to the limit at 9,600rpm, letting it pull much harder after each gear change. There may be a lower top speed, but it gets there more quickly and that is where you can find a lot of performance.
     
    • Like Like x 6
    • Informative Informative x 2
    • Friendly Friendly x 1
    • List
  2. Henri
    OFFLINE

    Henri New Member Member

    19
    8
    Jan 24, 2018
    Love this update - The vintage 1971 track is awesome and beautifully made; the 917LH has much better handling capabilities than the 917K (both are fun on the old track)
     
  3. t0daY
    OFFLINE

    t0daY Head of RSR Admin

    3,886
    2,791
    Aug 2, 2016
    Stay tuned at the calendar, there might be something coming soonish ;)
     
    • Like Like x 1
    • Informative Informative x 1
    • List
  4. SBart_uk
    OFFLINE

    SBart_uk Active Member Member

    162
    81
    Mar 4, 2017
    Its a really fun car to drive on the unruined lemans track but its got absolutely horrific understeer between 40 & 100 mph...its like someone removes the front tyres and the only way to turn is to lock up the rears and flick it round... very much looking forward to a race there though :D
     
    • Like Like x 1
    • Agree Agree x 1
    • List
  5. drukqs
    OFFLINE

    drukqs Well-Known Member Member

    313
    172
    Oct 2, 2017
    really awesome update. drove the vintage track with the Ferrari and its a blast :)

    Hope we get this combo soon :D.

    Interestingly i drove against 31 AI's directly to race and Porsche were top 16 cars and then Ferrari's. I wonder if the game knows the Porsche is probably faster?
     
  6. Zemke
    OFFLINE

    Zemke Active Member Member

    145
    113
    Feb 8, 2018
    Do we need to remake all new setups for cars, as we did with the 1.5 patch?
     
  7. Cluck
    OFFLINE

    Cluck Super Moderator Moderator

    2,192
    1,473
    Aug 28, 2016
    Supposedly not. Only thing you can do is try your setup and see if it still feels OK. The tyres on quite a few cars have had some tweaks, so if you've tuned the car around the old tyre feel then you 'might' have to re-tune it. But really, it's down to feel and personal preference :)
     
    • Informative Informative x 2
    • List
  8. SBart_uk
    OFFLINE

    SBart_uk Active Member Member

    162
    81
    Mar 4, 2017
    I don't think you ever actually needed to do it, It just meant they might not work as they did before I think. Its pretty hard to tell now what might have changed anyway as for some strange reason they wont release proper patch notes anymore...
     
  9. Cluck
    OFFLINE

    Cluck Super Moderator Moderator

    2,192
    1,473
    Aug 28, 2016
    The notes, sadly, won't ever return to being as verbose as they were pre patch 5. Part of the reason, from what was said when patch 4 arrived, is that the 1st-party testers (ie, Sony and Microsoft) will test everything that is in the notes and if any one item flags up it holds up the release - ergo, if SMS send in patch notes with 200 things in it, any one of those 200 items could cause the update to fail and result in a delay. I am guessing those rules also forbid them from even disclosing that info post-patch release but that is just a guess, I have no more information than that which SMS has stated in public (and even if I did, I doubt I'd be allowed to reveal it)

    Although it results in a bit of guesswork at times, all that matters is that we have a patch with a bunch of fixes in it. There's a very active thread on the pcars forum where people are keeping track of things that aren't working correctly pre- and post- patch, ticking things off as they discover they are fixed.
     
    Last edited: Jun 6, 2018
    • Informative Informative x 2
    • List
  10. Henri
    OFFLINE

    Henri New Member Member

    19
    8
    Jan 24, 2018
    That's what I did - the only thing is the repeatability of that move :shame:

    Same here - let's race
     
  11. SBart_uk
    OFFLINE

    SBart_uk Active Member Member

    162
    81
    Mar 4, 2017
    Thanks for the info Cluck. I wasn't aware of that and totally understand you cant reveal anything that's not public...
    Silly Consoles!!! is all I'll say ;) :D
     
  12. Cluck
    OFFLINE

    Cluck Super Moderator Moderator

    2,192
    1,473
    Aug 28, 2016
    Without consoles, there arguably wouldn't be a Project CARS 1 or 2. Like it or not, they make it financially viable.

    Anyhoo, I don't actually know any more than I've posted here, honestly. I am not privy to the business side of things at SMS, I only get to play test the DLC and patch content in advance of general release, mostly for screenshots.

    Anyhoo, we've gone off-topic long enough methinks :)

    This DLC does contain some bloody awesome content. It's worth way more than the asking price, no matter what your views on certain aspects of it are. Hurtling down the old Mulsanne straight at 240mph is a buzz like nothing else :)
     
    • Like Like x 3
    • Agree Agree x 1
    • List
  13. SBart_uk
    OFFLINE

    SBart_uk Active Member Member

    162
    81
    Mar 4, 2017
    Yup only joking :)...Just tried the Ferrari in time trial and wow that thing is FUN!
    240? Don't you mean 249? ;).
    My favorite DLC so far by a long long way :). I can only pray for some more vintage content at some point. Would love to see some more old 60's tracks like Kyalami, Reims, Mosport, Zandvoort etc etc...
     
    • Agree Agree x 3
    • Like Like x 2
    • Friendly Friendly x 1
    • List
  14. UnstopaPaul
    OFFLINE

    UnstopaPaul Well-Known Member Member

    382
    178
    Jan 4, 2018
    I just wish there were a few more liveries (real or fake) for some of these cars. I pity the commentator trying to keep track of 30 cars and only 2 liveries... :D
     
  15. Hujkis
    OFFLINE

    Hujkis Active Member Member

    223
    76
    Sep 27, 2017
    Absolutely love this!
    Sign me up for any Le Mans action :)